|
343721551
|
0418300
|
2019-01-17
|
2772 U.S. HIGHWAY 78 EAST, ANNISTON, AL, 36207
|
|
| Inspection Type |
Complaint
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2019-01-17
|
| Case Closed |
2019-04-18
|
Related Activity
| Type |
Complaint |
| Activity Nr |
1415931 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19100030 A01 |
| Issuance Date |
2019-03-22 |
| Current Penalty |
13260.0 |
| Initial Penalty |
13260.0 |
| Final Order |
2019-04-18 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Related Event Code (REC) |
Complaint |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.30(a)(1): Before any employee is exposed to a fall hazard, the employer did not provide training for each employee who uses personal fall protection systems or who was required to be trained as specified elsewhere in this subpart: a) On or about 01/15/2019 - Collision repair, employees removing and replacing RV rooftops at approximately 10 feet above the ground were unware of the hazard of falling. |
|
| Citation ID |
02001 |
| Citaton Type |
Repeat |
| Standard Cited |
19100028 B01 I |
| Issuance Date |
2019-03-22 |
| Current Penalty |
72931.0 |
| Initial Penalty |
72931.0 |
| Final Order |
2019-04-18 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Related Event Code (REC) |
Complaint |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.28(b)(1)(i): The employer did not ensure that each employee on a walking-working surface with an unprotected side or edge that was 4 feet (1.2 m) or more above a lower level was protected from falling by one or more of the following: Guardrail systems, safety net systems, or personal fall arrest systems: a) On or about 01/17/2019 - Collision repair shop, employees removing and replacing RV rooftops at approximately 10 feet above the ground were unprotected from falls. Emerald Coast RV Center, LLC was previously cited for a violation of this occupational safety and health standard or its equivalent standard 1910.28(b)(1)(i) was contained in OSHA inspection number 1221083, citation number 2, item number 1 and was affirmed as a final order on 05/31/2017, with respect to a workplace located at 2961 Ross Clark Circle SW, Dothan, AL 36301. Emerald Coast RV Center, LLC was previously cited for a violation of this occupational safety and health standard or its equivalent standard 1910.23(c)(1) which was contained in OSHA inspection number 924816, citation number 1, item number 1 and was affirmed as a final order on 12/20/13, with respect to a workplace located at 21282 Highway 59 South, Robertsdale, AL 36567. |
|
|
|
342210838
|
0418600
|
2017-03-30
|
2961 ROSS CLARK CIRCLE SW, DOTHAN, AL, 36301
|
|
| Inspection Type |
Complaint
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2017-03-30
|
| Case Closed |
2017-07-13
|
Related Activity
| Type |
Complaint |
| Activity Nr |
1194897 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19100178 A04 |
| Issuance Date |
2017-05-03 |
| Current Penalty |
4310.0 |
| Initial Penalty |
4310.0 |
| Final Order |
2017-05-31 |
| Nr Instances |
2 |
| Nr Exposed |
3 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.178(a)(4): Modifications and additions which affect capacity and safe operation of powered industrial truck were performed by the employer without the manufacturer's prior written approval: a) Shop Area: On or about March 30, 2017, and at times prior, the employer exposed employees to struck-by and crushed-by hazards in that employees were allowed to operate a forklift with a NewTec, Inc. 5th Wheel / Receiver Hitch Attachment that had not been certified by the manufacturer of the forklift and did not have updated instruction plates, tags, or decals. b) Shop Area: On or about March 30, 2017, and at times prior, the employer exposed employees to struck-by and crushed-by hazards in that employees were allowed to operate a forklift with a 5th Wheel / Receiver Hitch Attachment of unknown manufacturer, that had not been certified by the manufacturer of the forklift and did not have updated instruction plates, tags, or decals. |
|
| Citation ID |
01002 |
| Citaton Type |
Serious |
| Standard Cited |
19100178 Q07 |
| Issuance Date |
2017-05-03 |
| Current Penalty |
6464.0 |
| Initial Penalty |
6464.0 |
| Final Order |
2017-05-31 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.178(q)(7): Industrial trucks were placed in service after the examination revealed condition(s) adversely affecting the safety of the vehicle. Reported defects were not corrected. a) Shop Area: On or about March 30, 2017, and at times prior, the employer exposed employees to struck-by hazards in that employees were allowed to operate a forklift without a working horn. |
|
| Citation ID |
02001 |
| Citaton Type |
Repeat |
| Standard Cited |
19100028 B01 I |
| Issuance Date |
2017-05-03 |
| Abatement Due Date |
2017-05-15 |
| Current Penalty |
15210.0 |
| Initial Penalty |
15210.0 |
| Final Order |
2017-05-31 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Related Event Code (REC) |
Complaint |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.28(b)(1)(i): The employer did not ensure that each employee on a walking-working surface with an unprotected side or edge that was 4 feet (1.2 m) or more above a lower level was protected from falling by one or more of the following: Guardrail systems, safety net systems, or personal fall arrest systems: a) Shop Area: On or about March 30, 2017, and at times prior, the employer failed to provide fall protections such as but not limited to guardrails or personal fall arrest systems to protect employees from falls of greater than 4 feet while working on top of recreational vehicles/campers. Emerald Coast RV Center, LLC. dba Camping World was previously cited for a violation of this occupational safety and health standard or its equivalent standard 1910.23(c)(1), which was contained in OSHA inspection number 924816, citation number 1, item number 1 and was affirmed as a final order on 12/20/13, with respect to a workplace located at 21282 Highway 59 South, Robertsdale, AL 36567. |
|
| Citation ID |
02002 |
| Citaton Type |
Repeat |
| Standard Cited |
19100178 L01 I |
| Issuance Date |
2017-05-03 |
| Current Penalty |
10140.0 |
| Initial Penalty |
10140.0 |
| Final Order |
2017-05-31 |
| Nr Instances |
2 |
| Nr Exposed |
3 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.178(l)(1)(i): The employer did not ensure that each powered industrial truck operator was competent to operate a powered industrial truck safely, as demonstrated by the successful completion of the training and evaluation specified in this paragraph (l): a) Shop Area: On or about March 30, 2017, and at times prior, the employer exposed employees to struck-by hazards in that employees were allowed to operate a forklifts without the employer first ensuring the employees were competent to operate the equipment as demonstrated by the completion of the required training and evaluation specified in the regulation. Emerald Coast RV Center, LLC. dba Camping World was previously cited for a violation of this occupational safety and health standard or its equivalent standard 1910.178(l)(1)(i), which was contained in OSHA inspection number 924816, citation number 1, item number 2 and was affirmed as a final order on 12/20/13, with respect to a workplace located at 21282 Highway 59 South, Robertsdale, AL 36567. |
|
| Citation ID |
03001 |
| Citaton Type |
Other |
| Standard Cited |
19101200 F05 |
| Issuance Date |
2017-05-03 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2017-05-31 |
| Nr Instances |
2 |
| Nr Exposed |
3 |
| Related Event Code (REC) |
Complaint |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.1200(f)(5): The employer did not ensure that each container of hazardous chemicals in the workplace was labeled, tagged, or marked with the identity and appropriate hazard warnings regarding the chemicals contained therein: a) Detail Area (On shelf): On or about March 30, 2017, and at times prior, the employer exposed employees to respiratory and other hazards associated with the use of chemicals such as but not limited to Bleach, Soap (A-Foam Cleaner), Air Freshener (Ardex Aromatherapy), and Acids (Attack Acid Truck Cleaner), in that employees were allowed to move chemicals to small bottles that were not labeled and not intended for single use. b) Detail Area (On top of cabinet): On or about March 30, 2017, and at times prior, the employer exposed employees to respiratory and other hazards associated with the use of chemicals such as but not limited to Bleach, Soap (A-Foam Cleaner), Air Freshener (Ardex Aromatherapy), and Acids (Attack Acid Truck Cleaner), in that employees were allowed to move chemicals to small bottles that were not labeled and not intended for single use. |
|
|
|
339248163
|
0418600
|
2013-08-02
|
21282 HIGHWAY 59 SOUTH, ROBERTSDALE, AL, 36567
|
|
| Inspection Type |
Complaint
|
| Scope |
Partial
|
| Safety/Health |
Health
|
| Close Conference |
2013-08-02
|
| Emphasis |
L: FORKLIFT, N: AMPUTATE, L: FALL
|
| Case Closed |
2014-01-15
|
Related Activity
| Type |
Complaint |
| Activity Nr |
835566 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19100023 C01 |
| Issuance Date |
2013-12-05 |
| Abatement Due Date |
2013-12-13 |
| Current Penalty |
2500.0 |
| Initial Penalty |
4000.0 |
| Final Order |
2013-12-20 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Related Event Code (REC) |
Complaint |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.23(c)(1): Open-sided floors and/or platforms four feet or more above adjacent floor or ground level were not guarded with standard railings (or equivalent). a) Shop Area: On or about August 2, 2013 and at times prior; the employer failed to provide fall protection such as but not limited to guardrails or personal fall arrest systems to protect employees from falls of up to 12 feet while working on top of recreational vehicles. |
|
| Citation ID |
01002 |
| Citaton Type |
Serious |
| Standard Cited |
19100178 L01 I |
| Issuance Date |
2013-12-05 |
| Abatement Due Date |
2013-12-13 |
| Current Penalty |
3000.0 |
| Initial Penalty |
7000.0 |
| Final Order |
2013-12-20 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.178(l)(1)(i): The employer did not ensure that each powered industrial truck operator is competent to operate a powered industrial truck safely, as demonstrated by the successful completion of the training and evaluation specified in this paragraph (l). a) On or about August 2, 2013 and at times prior; the employer exposed employees to struck-by hazards in that employees were allowed to operate a powered industrial truck without the employer first ensuring the employees were competent to operate the equipment as demonstrated by the completion of the required training and evaluation specified in the regulation. |
|
| Citation ID |
01003 |
| Citaton Type |
Serious |
| Standard Cited |
19100213 C01 |
| Issuance Date |
2013-12-05 |
| Abatement Due Date |
2013-12-13 |
| Current Penalty |
2500.0 |
| Initial Penalty |
5000.0 |
| Final Order |
2013-12-20 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.213(c)(1): Circular handfed ripsaw(s) were not guarded by an automatically adjusting hood which completely enclosed that portion of the saw above the table and above the material being cut. a)Shop Area: On or about August 2, 2013 and at times prior; employees were exposed to amputation hazards when operating a table saw without a guard. |
|
| Citation ID |
01004 |
| Citaton Type |
Serious |
| Standard Cited |
19100242 B |
| Issuance Date |
2013-12-05 |
| Abatement Due Date |
2013-12-13 |
| Current Penalty |
2500.0 |
| Initial Penalty |
4000.0 |
| Final Order |
2013-12-20 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.242(b): Compressed air used for cleaning purposes was not reduced to less than 30 p.s.i. a) Shop area: On or about August 2, 2013 and at times prior; the employer exposed his employees to compressed air hazards in that employees were permitted to use compressed air that was not reduced to less than 30 psi for cleaning. |
|
| Citation ID |
01005 |
| Citaton Type |
Serious |
| Standard Cited |
19100253 B02 II |
| Issuance Date |
2013-12-05 |
| Abatement Due Date |
2013-12-13 |
| Current Penalty |
2500.0 |
| Initial Penalty |
4000.0 |
| Final Order |
2013-12-20 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.253(b)(2)(ii): Cylinders were not stored in areas that the cylinders would not be knocked over. a) Shop Area: On or about August 2, 2013 and at times prior; the employer exposed employees to struck by hazards in that employees were allowed to walk and work in the same area where cylinders were stored but were not secured to prevent the cylinders from being knocked over. |
|
| Citation ID |
01006 |
| Citaton Type |
Serious |
| Standard Cited |
19100305 B01 II |
| Issuance Date |
2013-12-05 |
| Abatement Due Date |
2013-12-13 |
| Current Penalty |
2500.0 |
| Initial Penalty |
4000.0 |
| Final Order |
2013-12-20 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.305(b)(1)(ii): Unused openings in boxes, cabinets, or fittings were not effectively closed. a) Shop Area: On or about August 2, 2013 and at times prior; the employer exposed his employees to arc blast and fire hazards in that the employees were allowed to walk and work around the electrical box that is missing a breaker blank. |
|
| Citation ID |
01007 |
| Citaton Type |
Serious |
| Standard Cited |
19100305 B02 I |
| Issuance Date |
2013-12-05 |
| Abatement Due Date |
2013-12-13 |
| Current Penalty |
2500.0 |
| Initial Penalty |
5000.0 |
| Final Order |
2013-12-20 |
| Nr Instances |
2 |
| Nr Exposed |
1 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.305(b)(2)(i): Each outlet box in completed installations did not have a cover, faceplate, or fixture canopy. a) Shop Area, Bay 4: On or about August 2, 2013 and at times prior; the employer exposed his employees to electrocution hazards in that the employees were allowed to plug the recreational vehicles in a 110 V outlet that is missing the faceplate. b) Shop Area, end of Bay 4: On or about August 2, 2013 and at times prior; the employer exposed his employees to electrocution hazards in that the employees were allowed to use, walk and/or work an outlet that is missing the faceplate. |
|
| Citation ID |
01008 |
| Citaton Type |
Serious |
| Standard Cited |
19100305 G01 IV |
| Issuance Date |
2013-12-05 |
| Abatement Due Date |
2013-12-13 |
| Current Penalty |
2500.0 |
| Initial Penalty |
4000.0 |
| Final Order |
2013-12-20 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.305(g)(1)(iv): Unless specifically permitted otherwise in paragraph (g)(1)(ii) of this section, flexible cords and cables may not be used as a substitute for the fixed wiring of a structure. a) Shop Area: On August 2, 2013 and at times prior; the employer exposed employees to electrical or fire hazards by allowing temporary wiring (extension cords) that run through the wall and frames of the building to be used as permanent wiring to provide power to several appliances in the shop. |
|
| Citation ID |
01009A |
| Citaton Type |
Serious |
| Standard Cited |
19101200 E01 I |
| Issuance Date |
2013-12-05 |
| Abatement Due Date |
2013-12-13 |
| Current Penalty |
2500.0 |
| Initial Penalty |
4000.0 |
| Final Order |
2013-12-20 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.1200(e)(1)(i): The written hazard communication program did not include a list of the hazardous chemicals known to be present, using an identity that was referenced on the appropriate material safety data sheet: (a) Shop Area: On or about August 2, 2013 and at times prior; the employer exposed employees to burns, intoxication and/or fire hazards in that employees were allowed to handle chemicals like oxygen, acetylene, argon, recreational vehicles batteries containing sulfuric acid, paints, diesel and chemical cleaners without being provided with a list of the hazardous chemicals available on site. |
|
| Citation ID |
01009B |
| Citaton Type |
Serious |
| Standard Cited |
19101200 H01 |
| Issuance Date |
2013-12-05 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-12-20 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.1200(h)(1): Employees were not provided effective information and training on hazardous chemicals in their work area at the time of their initial assignment and whenever a new hazard that the employees had not been previously trained about was introduced into their work area. (a) Shop area: On or about August 2, 2013 and at times prior; the employer exposed employees to burns, intoxication and/or fire hazards in that employees were allowed to handle chemicals like oxygen, acetylene, argon, recreational vehicles batteries containing sulfuric acid, paints, diesel and chemical cleaners without trained on the methods that may be used to protect themselves from health and safety hazards. |
|
| Citation ID |
02001 |
| Citaton Type |
Other |
| Standard Cited |
19100134 C02 |
| Issuance Date |
2013-12-05 |
| Abatement Due Date |
2013-12-13 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-12-20 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.134(c)(2): The employer did not develop and implement a respiratory protection program in accordance with sections i and ii of this paragraph (c)(2) for employees who chose to wear respirators where respirator use was not required. a) Shoparea: On or about August 2, 2013 the employer failed to develop and implement a written respiratory protection program exposing the employees who use respirator to respiratory hazards. |
|
|
